Backcountry Forum
Backpacking & Hiking Gear

Backcountry Forum
Our long-time Sponsor - the leading source for ultralite/lightweight outdoor gear
 
 
 

Amazon.com
Backpacking Forums
---- Our Gear Store ----
The Lightweight Gear Store
 
 WINTER CAMPING 

Shelters
Bivy Bags
Sleeping Bags
Sleeping Pads
Snow Sports
Winter Kitchen

 SNOWSPORTS 

Snowshoes
Avalanche Gear
Skins
Hats, Gloves, & Gaiters
Accessories

 ULTRA-LIGHT 

Ultralight Backpacks
Ultralight Bivy Sacks
Ultralight Shelters
Ultralight Tarps
Ultralight Tents
Ultralight Raingear
Ultralight Stoves & Cookware
Ultralight Down Sleeping Bags
Ultralight Synthetic Sleep Bags
Ultralight Apparel


the Titanium Page
WM Extremelite Sleeping Bags

 CAMPING & HIKING 

Backpacks
Tents
Sleeping Bags
Hydration
Kitchen
Accessories

 CLIMBING 

Ropes & Cordage
Protection & Hardware
Carabiners & Quickdraws
Climbing Packs & Bags
Big Wall
Rescue & Industrial

 MEN'S APPAREL 

Jackets
Shirts
Baselayer
Headwear
Gloves
Accessories

 WOMEN'S APPAREL 

Jackets
Shirts
Baselayer
Headwear
Gloves
Accessories

 FOOTWEAR 

Men's Footwear
Women's Footwear

 CLEARANCE 

Backpacks
Mens Apparel
Womens Apparel
Climbing
Footwear
Accessories

 BRANDS 

Black Diamond
Granite Gear
La Sportiva
Osprey
Smartwool

 WAYS TO SHOP 

Sale
Clearance
Top Brands
All Brands

 Backpacking Equipment 

Shelters
BackPacks
Sleeping Bags
Water Treatment
Kitchen
Hydration
Climbing


 Backcountry Gear Clearance

Topic Options
Rate This Topic
#196626 - 09/21/16 04:22 PM down quilt, lessons learned
Bob Chiang Offline
member

Registered: 11/05/10
Posts: 23
Loc: New York, USA
Hi all,

I just finished a down quilt and you can see pictures here:
14 ounce 3" loft down quilt

I haven't made anything down-filled since the late 1970's when I made a sleeping bag and sweater from Frostline kits, and a vest. I learned a few things that hopefully others may find helpful.

1) Working with down is not necessarily a messy operation. I transferred handfuls of down from the vendor's plastic bags to the quilt with no significant loss. There was no need to vacuum after I finished. Only a very few stray plumes have shown up in the room. My lessons were:
-Work in a room with no draft.
-Move very slowly.
-If a few plumes or a clump of down falls, don't try to catch them until you're done transferring your handful. Then move in slow motion to gather them and pick them up.
-Don't compress either the source-bag or the destination fabric that would create airflow.

2) Make the baffles narrower than the desired loft. I made my baffles almost the same as the desired loft thickness. The design quantity of down provided the desired loft while the quilt was laid flat, but settled when the quilt was held vertically.

3) I think a 12" square karo baffle spacing is marginally acceptable to maintain even loft.

4) I think the baffled "pockets" on the sides of a quilt especially should be smaller. The sides of the quilt will hang vertically and the baffles should be more closely spaced to prevent settling.

I ended up adding more down than I intended by design to reduce the settling, and ended up with a considerably loftier & slightly heavier quilt than I originally wanted.

The plan is to test it out this coming weekend in the high peaks region of the Adirondacks. Weather forecast is for sub-freezing temperatures at night.

Have Fun,
-Bob

Top
#196629 - 09/22/16 06:02 PM Re: down quilt, lessons learned [Re: Bob Chiang]
BarryP Offline
member

Registered: 03/04/04
Posts: 1574
Loc: Eastern Idaho
"...and ended up with a considerably loftier & slightly heavier quilt than I originally wanted. "

14oz is pretty light. What did you 'originally want'?
Nice job.
-Barry
-The mountains were made for Tevas

Top
#196700 - 10/04/16 04:59 PM Re: down quilt, lessons learned [Re: BarryP]
Bob Chiang Offline
member

Registered: 11/05/10
Posts: 23
Loc: New York, USA
Hi Barry,

I don't mean to complain about the weight. I had originally intended the quilt to have about 2.2 to 2.5 inches of loft for just sub-freezing temperatures, at a calculated weight of about 12 ounces.

I'm happy about a 3+ inch loft quilt at 14 ounces, but it only seems to achieve that with careful distribution of the down. I feel like the baffle spacing I used allows too much migration especially along the sides. If I make another, I'd either use a tighter baffle pattern or tubes. And I'll be tempted to use longitudinal tubes at least for the main part of the body to prevent down from dropping down the sides of the quilt.

I did get to test it out in the Adirondacks at the end of September where temperatures dropped below freezing at night. The quilt was good, but I felt cold coming through my pad (still learning about hammocks). Adirondacks Dix Range trip

Have Fun,
-Bob

Top
#196736 - 10/07/16 10:43 PM Re: down quilt, lessons learned [Re: Bob Chiang]
Dryer Offline

Moderator

Registered: 12/05/02
Posts: 3591
Loc: Texas
Nice job on you quilt and thanks for the tips!
I was wondering if you gave some thought to using a 'down eductor' made from PVC pipe and a shop vac? I was going to use this method on my next down project.
Go to this link and scroll down a few posts to the Down Eductor diagram:
https://backpackinglight.com/forums/topic/33573/

He also has a video of the process in his next post.
_________________________
paul, texas KD5IVP

Top
#196867 - 10/29/16 10:57 AM Re: down quilt, lessons learned [Re: Bob Chiang]
Petro1234 Offline
member

Registered: 10/27/16
Posts: 101
Loc: engeland
Where do you begin with making your own bag ? I know there are various baffle designs, what sort of sewing machine do you use, any tips or help?

Top

Shout Box

Highest Quality Lightweight Down Sleeping Bags
 
Western Mountaineering Sleeping Bags
 
Lite Gear Talk - Featured Topics
MSR Recall
by balzaccom
02/24/24 11:13 AM
Backcountry Discussion - Featured Topics
Yosemite Winter Rangers
by balzaccom
12/21/23 09:35 AM
Make Your Own Gear - Featured Topics
Featured Photos
Spiderco Chaparral Pocketknife
David & Goliath
Also Testing
Trip Report with Photos
Seven Devils, Idaho
Oat Hill Mine Trail 2012
Dark Canyon - Utah
Who's Online
0 registered (), 56 Guests and 0 Spiders online.
Key: Admin, Global Mod, Mod
Newest Members
Noodles, McCrary, DanyBacky, Rashy Willia, WanderBison
13240 Registered Users
Forum Links
Disclaimer
Policies
Site Links
Backpacking.net
Lightweight Gear Store
Backpacking Book Store
Lightweight Zone
Hiking Essentials

Our long-time Sponsor, BackcountryGear.com - The leading source for ultralite/lightweight outdoor gear:

Backcountry Forum
 

Affiliate Disclaimer: This forum is an affiliate of BackcountryGear.com, Amazon.com, R.E.I. and others. The product links herein are linked to their sites. If you follow these links to make a purchase, we may get a small commission. This is our only source of support for these forums. Thanks.!
 
 

Since 1996 - the Original Backcountry Forum
Copyright © The Lightweight Backpacker & BackcountryForum